Large rooms: what actually covers 800 sq ft

Nearly 35 gallons a day, which is twice the biggest evaporative here and three times any portable. A steam humidifier boils water with electrodes and injects the steam into the ductwork, so unlike every evaporative unit it does not care whether the supply air is warm - it makes its own heat. That is what lets it serve a 10,000 sq ft house, and it is also why it needs a dedicated 240V circuit and why installation runs $1,800 to $4,200. There is no water panel to buy, but Aprilaire asks for a new $110 steam canister every year and new electrode wires every three. It publishes capacity by voltage and current draw rather than a wattage; boiling 34.6 gallons a day takes roughly 4 kW.

The fix for the bypass units' one real flaw. A fan-powered humidifier has its own blower, so it can run independently of the furnace - on a mild day when the heat barely cycles, this one still humidifies and a 500 or 600 does not. It also needs no bypass duct, which makes it the easier install where the furnace is tight against a wall. Eighteen gallons a day and 5,300 sq ft claimed for a tightly built home; Aprilaire's older selection guide put this model at 2,100 sq ft for an average house against 4,200 tight. The load calculation lands at about 4,400.

Eighteen gallons a day against a published 4,500 sq ft - almost exactly what the load calculation says 18 gal/day supports, which makes this the most precisely honest coverage claim of any whole-house unit here. Like the Aprilaire 700 it carries its own blower, so it humidifies on mild days when a bypass unit sits idle, and Honeywell specifically recommends it with variable-speed and multi-stage furnaces where the burner cycles less. It undercuts the Aprilaire 700 by $60 on hardware.

The best-selling whole-house humidifier in North America, and the default recommendation from most HVAC contractors for a reason: seventeen gallons a day for $220 of hardware and $25 a year of water panels. The published 5,000 sq ft is the tight-construction figure, and Aprilaire says plainly that an average home of about 2,000 to 2,500 sq ft is the realistic target - a maker volunteering that its headline number applies to a minority of houses. The load calculation puts 17 gal/day at around 4,200 sq ft, neatly between Aprilaire's own two figures.

Honeywell's direct answer to the Aprilaire 600, matching it at seventeen gallons a day. Honeywell quotes its coverage twice on the same page: "up to 4000 sq. ft." in the features and "up to 18,000 cubic feet" in the spec table - and 18,000 cubic feet at an eight-foot ceiling is only 2,250 sq ft, so the two figures do not describe the same house. The square-foot figure is the one it markets, and against seventeen gallons a day, which supports about 4,200 sq ft, it is close to honest. The PerfectFLO tray meters water onto the pad instead of flooding it, which is where the water-saving claim comes from.

Twelve gallons a day puts it level with the H12-400HB at the top of the portables in this catalog, and it is the reason people with genuinely dry old houses end up here rather than buying four bedroom units. The load calculation puts 12 gal/day at around 2,950 square feet against AIRCARE's 3,600 - an overstatement of about a fifth, which in this category counts as restraint. The number that surprises people is the tank: 3.6 gallons feeding 12 gallons a day is roughly seven hours at full output. The 36-hour figure is the lowest of four speeds. Owners of dry houses fill this thing twice a day in January and consider it worth it.

The MA1201's output in the wood-finish cabinet AIRCARE calls the Alliance, with half again as much water, which is the version of this machine that makes sense for a house you actually live in. Same 12 gallons a day, but 5.4 gallons of reservoir stretches the fill interval from seven hours to eleven at full tilt, and four speeds with an auto humidistat mean it rarely runs at full tilt. It is heavy and it is furniture, but it does a job that otherwise requires a plumber and a hole in your ductwork. Not to be confused with AIRCARE's Credenza, a different 5.6-gallon, nine-speed model.

Bolted to the ductwork, plumbed to a water line, and never filled by hand again - that is the entire argument for going whole-house, and the Aprilaire 500 is the small end of it. A bypass humidifier borrows warm air from the supply duct, passes it through a wet evaporator panel, and returns it to the return duct; it only humidifies while the furnace is running, which is its main limitation. Twelve gallons a day matches the biggest portable console in this catalog, and the 3,600 sq ft claim sits about a fifth above what the load calculation supports. Aprilaire publishes separate figures for tight, average and loose construction, which is a more honest way to state coverage than anyone selling a plug-in unit manages.

This is what happens when Levoit stops building ultrasonics. A 1,500 mL/hr published output works out to 9.5 gallons a day, which is console territory, and because it evaporates water through wicks rather than atomising it there is no white dust and no mineral film on the furniture. The 3,000 sq ft claim is one of the more defensible in the catalog: the physics supports around 2,300, so it overstates by about a third rather than the three- and four-fold gaps common among the ultrasonics. The cost is a wick habit - four of them, around $40 a set - and a unit you fill through a hose and funnel rather than lifting a tank. Owners who moved from an ultrasonic mostly describe the absence of dust as the thing they noticed first.

AIRCARE's concession to the fact that a console humidifier is a large brown box in a living room. The EP9800 is the same machinery in a pedestal cabinet with a wood finish, meant to look like furniture rather than an appliance - and it half succeeds, which is more than the MA1201 attempts. Nine fan speeds is genuinely useful granularity when you are trying to find the setting that is quiet enough to live with. Output is 7.4 gallons a day against a 2,400 sq ft claim; the calculation supports about 1,820, so it overstates by a third.

Four gallons of water, four gallons a day of output, a full day between fills at the top speed, and a 1,000 sq ft claim that the load calculation puts at 985. Vornado states the runtime honestly too - four gallons in 24 hours run continuously on high - which is the sentence almost nobody else in this category is willing to write. It is the smallest true console here and the one to buy if the AIRCARE units are more furniture than a room can take. Made in the USA, five-year guarantee, and still just a fan blowing through two wet wicks.

Four gallons a day from a tabletop unit, which puts the U700 level with Vornado's Evap40 console on output while taking up a fraction of the floor. Its 1,000 sq ft figure lands within two percent of the load calculation - Boneco and Vornado both print numbers the physics backs up. Its nine-litre tank still lasts only fourteen hours at full tilt, which is the recurring lesson of this category: capability and refill interval trade against each other and no amount of marketing changes it. The self-cleaning mode is genuinely unusual at any price.

The EVDC300's larger sibling: same DC motor and single-watt idle, two tanks instead of one, and enough output to matter in a real living room. At 3.5 gallons a day it is the most capable tabletop Vornado makes, and its 840 sq ft figure again sits within a few percent of the load calculation. Fourteen hours at full output, so still a daily job in a dry house - but two tanks make that a lighter job than one. The question it poses against the Evap40 console is whether you would rather carry water twice a day and keep the floor space, or once a day and give up a corner.

One of the few units in the catalog where the maker publishes an actual output rate rather than leaving you to infer it: 550 mL/hr on warm, 300 on cool. That makes the LV600S checkable in a way most of its shelf-mates are not, and the check is unflattering in a useful way. At 550 mL/hr it moves 3.49 gallons a day, which is a genuinely capable figure - enough for around 860 square feet by the psychrometrics - but it empties the 6L tank in about eleven hours. The 50-hour runtime on the box is the cool setting at its lowest. Both numbers are honest; they just describe different machines. Owners who understand that and run it on auto in a bedroom are happy; owners who expected 50 hours of whole-floor humidification are the ones writing the angry reviews.

Eight litres, warm and cool mist and a published 550 mL/hr - on paper the most complete portable in Dreo's line, though the demineralisation cartridge that would stop white dust is a separate purchase: $25.99 for three, or a $145.98 listing that bundles one against $119.99 without. The extra two litres over the HM713S buy about two and a half more hours at full output rather than the twenty the runtime figures suggest, because the 80-hour number is again the lowest setting. Where it genuinely earns the money is the middle: run it on auto in a 400 sq ft bedroom and it will go two or three nights between fills without a chilly mist.

Dreo publishes 500 mL/hr for this one, which is 3.17 gallons a day and puts it in the same real-output bracket as Levoit's LV600S at a slightly lower price. Like the Levoit, it makes white dust on hard tap water unless you add a demineralisation cartridge, which Dreo sells separately. The 500 sq ft claim is well inside what 3.17 gal/day actually supports - around 780 by the psychrometrics - making this one of the few portable ultrasonics whose room-size number is conservative rather than aspirational. The catch is the same as every hybrid: at the output that justifies the claim, the 6-litre tank is empty in about twelve hours.

Swiss, expensive, and unusually straight about what it does: 3.17 gallons a day published, against a 650 sq ft claim that the load calculation puts at 780. A maker printing a number 17% below what its own output supports is doing something almost nobody else in this catalog does. It pairs a demineralisation cartridge with an Ionic Silver Stick for the water, so the two failure modes of a cheap ultrasonic - dust on the furniture, life in the tank - both have a specific countermeasure. The tank is only 5 litres, which at full output is about ten hours.

The One Plus with a heater, which buys warm mist and - more interestingly - a one-touch cycle that boils the tank to sterilise it. Between a steel water path and a heat-sanitise button, this is as close as the category gets to solving the hygiene problem outright, and it is priced accordingly at $450. Carepod buries its output rate in a feature graphic rather than a spec table, which is a shame because it is one of the better ones here: 440 mL/h on warm is 2.79 gallons a day, and that makes the 700 sq ft on the listing very nearly honest. The catch is the tank. At that output 4.2 litres is gone in about ten hours, against the 32 advertised at the lowest setting.